Ingersoll Rand's Air Quality Solutions
Introduction
Compression the hot dryer is a pair tower type,dryer design.Compression the renewable hot dryer is the most efficient dryer.it can naturally recover the quantity of hot generated by the process of compressor.this "free"heat as used to the air drying process, in the provision of dry air at the same time,almost did not spend any energy.
Reliability
Ingersoll Rand Company H series and HC series compressor hot dryer is the world's most simple and most reliable renewable dryer,innovative design and outstanding operating performance,to ensure the reliability of the compressed air system
Inersoll Rand compressed hot renewable dryer with high performance dual-valve,to ensure a long period of trouble-free operation
Compression hot renewable dryer unique design,comes with dehydration and cooling cycle to ensure that whole the year will reach below -40°F the dew point.
Compression hot of renewable dryer equipped with micro-processing control system to maintain its performance,and monitor the operation of equipment,reducing the downtime to a minimum.
H and series HC drying function and multi-compressors connected,thus not affecting the compressed air system under the integrity to provide a high level of flexibility.
Energy efficiency
Compressed hot dryer is to pretect the air pipeline,tools and expensive instrument the most cost effective equipment.H series dryer without the use of any heater or blower.only the operating costs of dealing with micro-controller is required for the power,generally less than 24v which is the same power consumption with light bulb.due to not use the heater or blower,H series of annual electricity costs less than $ 10.H series design not use the compressed air.
HC series can continue to provide below 40°F(40°)the dew point,the operation cost is at a fraction compare with other renewable dryer,or even one of the more than 1/10.
Compression renewable dryer of the design use the flow valve and a small pipeline,to minimize pressure drop.
Two kinds of alternative dryer system
H series dryer available instrument level air quality,and the initial investment and operating costs low.
HC series is a more advanced drying machine,comes with a dehydration and cooling cycle,could provide a sustainable and stable dew point,does not exist temperature or dew point fluctuations.
Ingersoll Rand company for the dryer configuration dew point control device,can be run in accordance with the actual demand switch drying tower.and this device features full use of the desiccant the absorption properties and the ability to reduce the number of drying tower of the switch,and will flow fluctuations to a minimum.
H series working principle
As to allow air from the compressor directly into the dryer,H series possess the campaign with the design of efficient performance.the air is directed into regeneration tower.here,compressed hot will remove the water from desiccant.
Then,the cooler after the air inflow in and then into the water vapor separator into the final drying tower.in this dryer,the air is dry to its lowest dew point.
HC Series of principle
Left tower heat
During the heating cycle,the hot air from the compressor through the double valve directly access to renewable tower,in the tower,the hot dry air to remove the desiccant in a lot of water,and then,after the cooler air to enter in the cool,then,water through the water vapor separator,and with no loss from the discharge valve.finally,air into the dry tower and was eventually asked to dry the dew point.
Left tower dehydration
Regeneration of dehydration stage in full flow after heating,normally takes 90 minutes continued,at the beginning of regeneration tower through muffler decompression.dehydration in the period,a small amount of dry air renewable be used to remove residual moisture in the tower,so that HC series provides a lower dew point.
Left cooling tower
After the end of the dehydration,renewable tower pressure,cooling began.in the cooling period,the part dry of the export air directly into the regeneration tower to reduce the temperature of the cooling bed. Cooling period there is no air loss.cooling and dehydration can provide the combination of very low dew point temperature.thereby avoiding the double towers of the switch during the dew point and temperature fluctuations.
Productivity
Compressed air system contains water vapor,such as air pipes will cause a rust and corrosion,pneumatic tools improper lubrication,labelling and packaging and product defects and other issues.compressed hot dryer can be renewable for a low dew point temperature,so you the operating system to avoid the resulting loss.
H series dryer can according to operating conditions provided under the 0°F(-18°C) to -40°F(-40°C)within the dew point temperature.H series dryer can transport be better air than the instrument of air quality.solution the water vapor problem.
HC series dryer patented dehydration and cooling cycle thchnology,it can provide for the whole year below -40°F(-40°C) dew point temperature.
H and HC series dryer's fine design can avoid the pollution caused by water vapor in a cut-off phenomenon.
Health,safety and environment
Ingersoll Rand company of the compression of renewable dryer is designed to further protect the operator and the use of environmental health and safety
Dryer use acid-free dry type,not because of the use refrigerants to have of ozone-depleting
Dryer insulation measures to protect the operator did not contact the surface heat
Compression of renewable dryer is the overall design,all pipes and cables have been connected,so free from the expensive installation costs,reducing the area. |
